- Open Access
Differential gene expression in recombinant Pichia pastoris analysed by heterologous DNA microarray hybridisation
Microbial Cell Factories volume 3, Article number: 17 (2004)
Pichia pastoris is a well established yeast host for heterologous protein expression, however, the physiological and genetic information about this yeast remains scanty. The lack of a published genome sequence renders DNA arrays unavailable, thereby hampering more global investigations of P. pastoris from the beginning. Here, we examine the suitability of Saccharomyces cerevisiae DNA microarrays for heterologous hybridisation with P. pastoris cDNA.
We could show that it is possible to obtain new and valuable information about transcriptomic regulation in P. pastoris by probing S. cerevisiae DNA microarrays. The number of positive signals was about 66 % as compared to homologous S. cerevisiae hybridisation, and both the signal intensities and gene regulations correlated with high significance between data obtained from P. pastoris and S. cerevisiae samples. The differential gene expression patterns upon shift from glycerol to methanol as carbon source were investigated in more detail. Downregulation of TCA cycle genes and a decrease of genes related to ribonucleotide and ribosome synthesis were among the major effects identified.
We could successfully demonstrate that heterologous microarray hybridisations allow deep insights into the transcriptomic regulation processes of P. pastoris. The observed downregulation of TCA cycle and ribosomal synthesis genes correlates to a significantly lower specific growth rate during the methanol feed phase.
The methylotrophic yeast Pichia pastoris is well established as expression host for heterologous proteins (reviewed by  and ). However, despite the high technological impact of P. pastoris, the physiological and genetic information is still rather scarce. The genome sequence has not been published, and in fact less than 100 complete gene sequences have been deposited with GenBank by the time of writing. Consequently, as for most other non-model species, no DNA microarrays are being manufactured. Hence, one of the most powerful tools for the investigation of changes in expression patterns is not available for this yeast species.
To circumvent this problem, heterologous hybridisation to commercially available DNA microarrays might be conceivable. In fact, the successful non-homologous probing to microarrays has been reported recently. These studies cover a wide variety of organisms, including bacteria , a yeast , but also plants  and metazoan organisms [6–9]. The highest number of cross-hybridisation experiments has been performed with human microarrays. Chismar et al.  report, for instance, that heterologous probing of human cDNA arrays allows to gain useful information about gene expression in various primates. Moody et al.  compared, furthermore, the reproducibility of species-specific and cross-species hybridisations by evaluation of microarray hybridisations of porcine and human samples to human cDNA arrays. They reported that results generated by heterologous hybridisation were as reproducible as by homologous hybridisation, and the correlation between data derived from porcine and human hybridisations was strong. As judged from EST sequences of the porcine genome, the authors propose, that stretches of at least 100 bp with high similarity to the human homologue are sufficient for hybridisation. Renn et al.  compared the performance of cDNA microarrays from an African cichlid fish (Astatotilapia burtoni) for the heterologous hybridisation with cDNAs from eight different fish species, some of them closely related (other cichlids) and others more distantly related (among them Atlantic salmon and guppy). They conclude that significant results are obtained even with distantly related species, however, the number of positive spots declines with the phylogenetic distance, as strikingly does the degree of measured regulation.
While yeasts share many morphological and physiological similarities, they represent a very heterogeneous group of fungal organisms, and a high degree of gene sequence similarity cannot be assumed a priori. When cDNA of the non-conventional yeast Zygosaccharomyces rouxii was probed by cross-hybridisation to Saccharomyces cerevisiae GeneFilters, only 155 ORFs out of the Z. rouxii genome could be reproducibly detected . Anyhow, 86 genes out of these showed altered expression patterns between non-stressed and salinity-stressed Z. rouxii cells and 38 genes behaved differently than the S. cerevisiae homologues, indicating that the information gained is limited but nevertheless useful. As judged from 26S ribosomal DNA sequences, Z. rouxii is assumed to be more closely related to S. cerevisiae than P. pastoris, but still, all three belong to the hemiascomycetes .
As there are not many genes characterised for P. pastoris, there is no simple way to assess the degree of gene sequence similarity between P. pastoris and S. cerevisiae. However, in many of the few genes sequenced, stretches of high similarity (score >75% over a length of at least 250 bp and more) can be identified. Most of the known genes belong to the carbon and energy metabolism or contribute to amino acid or protein synthesis. Another group of P. pastoris genes with known sequence belongs to pathways specific for methylotrophic yeasts. For these genes there are no homologues present in S. cerevisiae. Evidently, this respective fraction of the P. pastoris genome would remain unevaluated by heterologous hybridisation.
The main aims of this work are to verify whether a heterologous DNA array approach allows to obtain useful information for P. pastoris, and to identify genes that are specifically regulated upon a shift from glycerol to methanol as carbon and energy source. This shift is of particular interest since one of the specific features of methylotrophic yeasts is the tightly regulated methanol metabolism, which has been utilised for the construction of strong and tightly controlled expression vectors. The methanol induced promoter of the alcohol oxidase 1 (AOX1) gene, which is repressed by many carbon sources such as glucose, glycerol or ethanol, is widely used for heterologous gene expression in P. pastoris. Accordingly, methanol is often used as the carbon source that induces the production of heterologous proteins. In addition to heterologous protein induction, the shift of the carbon source to methanol causes major structural and physiological changes within the cell. The enzymes for methanol metabolism are synthesised de novo and some of them are translocated into peroxisomes. Strikingly, peroxisomes can fill most of the cellular volume and AOX1 alone can account for up to 35% of the total soluble protein . Additionally, heterologous protein production and environmental conditions like low fermentation pH have been proven to exert stress in recombinant P. pastoris . Hence, for a first study of the transcriptomic regulations of recombinant P. pastoris, we used a strain expressing human trypsinogen under control of the AOX1 promoter, under conditions that strongly influence the physiology of the host cells, as previously described [15, 16]. A series of microarray hybridisations was performed as depicted in table 1, first to qualify the feasibility of cross-species hybridisation, and secondly to analyse the effects of the substrate change in fed-batch fermentations.
Results and discussion
1. Qualification of heterologous hybridisation
Before analysing differential gene expression data, it was our intention to verify whether the heterologous hybridisation of S. cerevisiae DNA microarrays with P. pastoris cDNA results in significant data. Obviously, the intensity of a signal will depend both on the amount of the specific mRNA in the sample, and the sequence similarity with the respective gene of S. cerevisiae. Therefore, we compared the signals obtained from four microarrays hybridised with P. pastoris cDNA with four microarrays hybridised with S. cerevisiae cDNA (as a control), obtained from shake flask cultures.
To estimate the overall potential to obtain data, and the degree of loss of information, the total number of genes giving significant values, and those determined to be under a given threshold were compared (table 2). In average, 66 % of all genes present on the microarray were either only weakly transcribed, not similar enough to produce a significant signal or not present at all in P. pastoris. In contrast, by hybridisation with S. cerevisiae cDNA about 46 % of all genes remained undetected.
We analysed those genes of P. pastoris for which sequences were deposited in the GeneBank database for sequence similarities to the S. cerevisiae genome, and determined the number of significant spots on 6 microarrays. 66 % of the signals derived from genes with high similarity (score > 75 % along stretches longer than at least 250 bp) were significant, while of the moderately to weakly similar genes only 28 % of the signals were significant. This indicates that a high sequence similarity of a sub-sequence within a gene is sufficient for efficient hybridisation. Considering that the signal intensity will depend on sequence similarity and length, but also on mRNA abundance, it becomes obvious, however, that a distinct minimum threshold of similarity cannot be defined.
It was expected that the number of positive spots would be lower for heterologous hybridisation as compared to homologous hybridisation, but the relatively high number of significant values obtained in our experiment is very promising to achieve useful and new information from this technique. Nevertheless, we sought statistical evidence for the biological significance of hybridisation signals obtained with P. pastoris cDNA.
First of all, data obtained from microarrays that were hybridised with identical but differentially labelled samples (yellow experiment) were evaluated, showing very high correlation coefficients of 0.97 and 0.98, for S. cerevisiae and P. pastoris respectively (table 3 and Fig. 1A). The correlation of data from identical samples on different microarrays is somewhat lower (r = 0.86 – 0.92), due to different relative intensities on different chips.
Since usually the data of two samples on one microarray are to be compared, it was important to evaluate the reproducibility, expressed as the standard deviations of both values of each spot on microarrays hybridised with identical samples. Fig. 1B displays the standard deviations plotted against the mean relative intensities of all significant spots of such a P. pastoris experiment, showing that the standard deviations do not vary over a wide range of signal intensities, which is in concordance with the results of Moody et al. . 96 % of the signals have a relative standard deviation (s. d. divided by mean) below 0.2.
Furthermore, we evaluated the correlation between the signal intensities obtained from P. pastoris cDNA with that from S. cerevisiae cDNA (cells grown under the same conditions). A highly significant correlation (r = 0.72) was observed (Fig 1C). Considering expectable differences in gene expression, different sequence similarities and the fact that signals from two microarrays were compared, such a high correlation is remarkable and suggests that the data obtained are biologically meaningful. The results obtained are in line with the data published by Moody et al.  who showed a strong correlation between porcine and human samples on human microarrays. Our data also support Renn et al.  who demonstrated that both the number of significant spots and signal correlation of different fish samples on A. burtoni microarrays depended on the phylogenetic distances between sample species and test species.
To evaluate the significance level for up- and downregulation, the signals from yellow experiments were plotted one against the other (Fig. 1A). These values should obviously fall in the unregulated range. A threshold regulation factor of 1.5 (illustrated by the dotted lines) includes 99.1 % of all significant spots as not significantly different, which means that such a threshold would yield false positives for less than 1 % of the significant genes.
Finally, the global regulation pattern of P. pastoris and S. cerevisiae between pH 5.0 and 3.5 was compared by correlating all genes downregulated under acidic conditions (Fig. 1D). The correlation is highly significant (p < 0.01) with a correlation coefficient r = 0.51. Clearly, different gene regulation, as well as different degrees of sequence similarities contribute to a reduction of this correlation. Interestingly, the average fold signal change of regulated genes is lower for P. pastoris than for S. cerevisiae (correlation slope = 0.8). A similar observation was made for more distantly related fish species .
2. Analysis of gene regulation in P. pastoris
As an example for differential gene expression in this study, the level of transcripts during the methanol induction phase of a lab scale fermentation was compared to that during the glycerol feeding phase, both at pH 5.0, and at pH 3.0. Figure 2 shows the development of biomass over time along with the pH and indications of feed changes, and furthermore depicts the time points when the analysed samples were taken.
Of all genes that gave significant signals, we report those that showed significant differences upon the shift from glycerol to methanol under at least one condition (pH), and that have a defined function in S. cerevisiae.
Unsurprisingly, genes involved in the core carbon metabolism show a significantly different expression during methanol and glycerol metabolism (table 4). Almost no differences between the samples obtained at pH 5.0 and 3.0 were found. Fructose-1, 6-bisphosphatase was significantly upregulated at least in one sample, whereas fructose 1, 6-bisphosphate aldolase, glyceraldehyde-3-phosphate dehydrogenase, enolase, and pyruvate kinase were found to be downregulated on methanol. Transketolase expression was enhanced while the transaldolase transcript level was relatively reduced. Of these enzymes, fructose-1, 6-bisphosphatase and transketolase (among others) are needed for biomass synthesis on methanol. Some genes related to ATP production were found to be downregulated which appears plausible as the rate of energy consumption is lower at the significantly lower specific growth rate when methanol is the carbon source. The beta subunit of pyruvate dehydrogenase was significantly downregulated at pH 5.0, further indicating that methanol metabolism decreases the TCA cycle flux. The upregulation of pyruvate decarboxylase under at least one condition comes somewhat unexpected, because an increase of the flux to ethanol production appears questionable for cells growing on methanol.
Table 5 displays a list of ribosomal genes that are essentially all downregulated on methanol. Considering the decreased specific growth rate, a decrease of total RNA is generally expected due to a decreased overall protein synthesis. Interestingly, four histone genes that gave significant signals were not regulated at pH 5.0, but induced at pH 3.0.
Only a few amino acid biosynthesis genes appeared to be regulated (table 6), indicating that amino acid synthesis is turned on, both on glycerol and methanol, as mineral media were used throughout the experiment. A major exception was the significant regulation of the proteins involved in methionine metabolism. While the homologues to MET3, MET16 and MET17 were upregulated on methanol, the homologues to MET6, SAM1, SAM2 and SAH1 were downregulated. As shown in figure 3, the first group of enzymes catalyses the reduction and fixation of sulphur, while the second group drives the cycle responsible for methyl group donation. The reduction of this pathway in cells grown on methanol would imply a decrease of the flux from the C1-pool to methionine by MET6 (5-methyltetrahydrofolate-homocysteine S-methyltransferase), which catalyses the transport of activated methyl groups from 5-methyl-THF to homocysteine. These methyl groups are then passed on via S-adenosyl-methionine by a variety of S-adenosyl-L-methionine-dependent methyl transferases, many of them being involved in ribosomal subunit biogenesis, rRNA and tRNA-processing, mRNA capping and nuclear export – once again stressing the lower demand for protein synthesis rate upon growth on methanol.
Other significantly regulated groups of genes (table 7) belong to the thiamine biosynthesis, all being upregulated, and the so-called snooze genes related to the stationary phase. Two of these genes, SNZ1 and SNZ2, were differently regulated at pH 5 and pH 3, being repressed on methanol at pH 5 and induced at pH 3, while SNZ3 was repressed at pH 5, but did not yield a significant value at pH 3. However, the reported high sequence similarity of the S. cerevisiae SNZ genes will not enable a reliable differentiation of their regulation on microarrays. For S. cerevisiae it is reported that the highly homologous products of the SNZ gene family are involved in vitamin B6 (pyridoxal) synthesis . Zeidler et al.  postulated that pyridoxal is a precursor of thiamine in yeast. Accordingly, the SNZ genes have been reported to be induced both by thiamine and pyridoxal depletion . However, with the data obtained in our experiment we cannot interpret the differential behaviour of the SNZ and THI genes, since among the genes utilising thiamine-pyrophosphat (TPP) as cofactor, transketolase (TKL1) and pyruvate decarboxylase (PDC1, PDC5) are upregulated while PDB1 (pyruvate dehydrogenase beta-subunit) and presumably also α-ketoglutarate dehydrogenase (belonging to the TCA cyle) and DHAS (belonging to the methanol utilisation pathway) are downregulated.
Thioredoxin-related genes appeared to be regulated upon shift from glycerol to methanol, too (table 7). Those being downregulated at least in one sample (IMP cyclohydrolase, ribonucleotide reductase, and thioredoxin reductase) are involved in ribonucleotide synthesis, again indicating a decreased demand of RNA precursors. Thioredoxin peroxidase, on the other hand, which is involved in the regulation of cell redox homeostasis and response to oxidative stress by reducing H2O2 and peroxide radicals, tended to be upregulated. This was expected due to the higher amount of oxidative stress during methanol utilisation.
To verify the data obtained with microarrays with an independent method, a northern blot analysis of the total RNA samples from the culture grown at pH 5.0 was performed, using the respective P. pastoris homologous sequences to produce the probes (Fig. 4). The actin mRNA level was unchanged whereas the human trypsinogen mRNA level (as a positive control) was strongly induced on methanol, both as expected. MET17 and SAH1 exemplify differentially regulated genes identified by the microarray experiment (table 6). The data from the northern blot confirmed the results derived by microarray analysis, further underlining the reliability of the method.
Surprisingly, only minor differences in transcriptional regulation were observed between cultures grown at pH 5.0 and pH 3.0. Of course it has to be considered that not the direct effects of a shift in external pH was observed. Still, one could expect a different set of genes to be significantly regulated upon a shift to methanol metabolism at the different pH values. At pH 3.0 a decreased yield in biomass was detected as compared to cultures at pH 5.0, which is consistent with the observation of Hohenblum et al.  stating that low fermentation pH decreases the viability of P. pastoris. In order to compare the general behaviour of P. pastoris at different external pH to that of S. cerevisiae, we measured the intracellular pH (pHi) of the cells. The cells of the culture at pH 5.0 showed a pHi of 7.1 at the end of the glycerol phase, and of 7.2 the end of the methanol phase, whereas the pHi of both samples of the cultures at pH 3.0 was 7.3. Thus, no changes of the pHi were observed between cultures grown at the chosen pH values, which is in contrast to the behaviour of S. cerevisiae, where the pHi appears to be more dependent on the external pH [19, 20].
We could successfully demonstrate that it is possible to obtain new and valuable information about transcriptomic regulation in P. pastoris by probing S. cerevisiae DNA microarrays.
Specific regulation upon a shift from glycerol mineral medium to methanol mineral medium under conditions similar to a production process were analysed. As major effects we recognised a downregulation of TCA cycle genes, and a transcriptional decrease of genes related to ribonucleotide and ribosome synthesis. Furthermore, the supply of activated methyl groups via adenosyl methionine was reduced, indicating a decreased ribosome and tRNA synthesis, which is not surprising since the specific growth rate is significantly decreased during the methanol feed phase in comparison to the glycerol feed phase. Correspondingly, a downregulation of the energy metabolism upon methanol induction appears reasonable.
Only a few genes were differentially regulated when comparing expression differences between growth on glycerol and growth on methanol of a culture grown at pH 5.0 to one at pH 3.0. Among the few genes found are the SNZ genes and the histone genes, but a plausible hypothesis for the differential pH dependent regulation was not found. Interestingly, also the intracellular pH did not change between the different external conditions, indicating a major difference in pH regulation between P. pastoris and S. cerevisiae.
Materials and Methods
Unless stated otherwise, all chemicals were purchased from Merck Eurolab, and all enzymes for DNA manipulation were purchased from MBI Fermentas.
The expression strain used in this study was P. pastoris strain X33 (Invitrogen), a wild type strain which can grow on minimal media without supplements. The identity of the strain in use was verified by partial 26S ribosomal DNA sequencing (data not shown). The selection mechanism was based on the Zeocin™ resistance of the transformation vector. Transformation of the strain was carried out with a plasmid derived from pPICZαB (Invitrogen), containing the gene for human trypsinogen 1 . pPICZαB utilises the AOX1 promoter of P. pastoris and the α-factor leader sequence of S. cerevisiae for product secretion. The selected strain was of the methanol utilisation positive (mut+) phenotype, which means that it is fully capable to metabolise methanol as the sole carbon source.
As a control strain we used S. cerevisiae CEN.PK 113-5D (MATa, ura3) .
2. Shake flask cultivation of P. pastoris and S. cerevisiae
Shake flask cultures were performed at 28°C in YPD medium (2% peptone, 2% glucose, 1% yeast extract).
The cells were inoculated to an OD660 of 0.3 from a pre-culture grown over night.
For the yellow experiment the samples were taken in exponential phase after 5 h of growth (OD660 for S. cerevisiae: 0.89, P. pastoris: 1.2).
To assess differentially regulated genes the respective cultures were divided after 5 h of growth. One half was incubated as before, whereas the other half was supplemented with 250 mM acetic acid. Samples were collected after shaking for 1.5 h at 28°C. The pH of the untreated culture was 5. The pH of the acid treated culture was 3.5.
3. Fermentation of P. pastoris
Fed batch fermentations were performed with a MBR mini bioreactor with a final working volume of 2 l, essentially as described by Hohenblum et al. .
The media were as follows
PTM1 trace salts stock solution contained per litre
6.0 g CuSO4• 5H2O, 0.08 g NaI, 3.0 g MnSO4• H2O, 0.2 g Na2MoO4• 2H2O, 0.02 g H3BO3, 0.5 g CoCl2, 20.0 g ZnCl2, 65.0 g FeSO4• 7H2O, 0.2 g biotin and 5.0 ml H2SO4 (95 %-98 %). All chemicals for PTM1 trace salts stock solution were from Riedel-de Haën, except for biotin (Sigma), and H2SO4 (Merck Eurolab).
Batch medium contained per litre
23.7 ml H3PO4 (85 %), 0.6 g CaSO4• 2H2O, 9.5 g K2SO4, 7.8 g MgSO4• 7H2O, 2.6 g KOH, 40 g glycerol, 4.4 ml PTM1 trace salts stock solution.
Glycerol fed-batch solution contained per litre
632 g glycerol (100 %) and 12 ml PTM1 trace salts stock solution
Methanol fed-batch solution contained per litre
988 ml methanol (100 %) and 12 ml PTM1 trace salts stock solution
The dissolved oxygen was controlled at DO = 30 % with the stirrer speed (600 – 1200 rpm). Aeration rate was 100 l h-1 air, which was supplemented with oxygen (up to 25 %) after the begin of the fed batch. The temperature was 25°C, and the pH was controlled with NH3 (25 %).
Before starting the fermentation, the pH of 1.2 l batch medium was set to 5.0 with NH3 (25 %). The batch phase of approximately 32 h was followed by a 4 h fed batch with glycerol medium (feed rate 15.6 ml h-1), leading to a dry biomass concentration of approximately 40 g l-1. Then, the feed with methanol medium was started with a feed rate of 6.4 ml h-1. The fermentation was terminated 14 h after the methanol feed start. The pH was 5.0 during batch, and either kept at 5.0 throughout the fermentation, or decreased to 3.0 at the beginning of the glycerol fed batch. The final dry biomass concentration was 51.4 g l-1 at pH 5.0, and 46.7 g l-1 at pH 3.0.
Samples were taken at the end of the glycerol fed batch phase and at the end of the methanol fed batch phase, respectively, as depicted in figure 2.
4. mRNA preparation
The cell pellets were re-suspended in 10 × the volume of TRI-reagent (Sigma) and frozen.
The samples were thawed on ice and after addition of acid washed glass beads the cells were homogenised in a Ribolyser (Hybaid Ltd.) for 2 × 20 sec, in between cooling on ice. After addition of chloroform, the samples were centrifuged and the total RNA was precipitated from the aqueous phase adding isopropanol. The pellet was washed 2 × with 70% ethanol, dried and re-suspended in RNAse free water. mRNA was isolated using the MicroPoly(A)Purist mRNA purification Kit (Ambion) according to the manufacturers protocol.
5. Synthesis and labelling of cDNA
5 μg of mRNA and 0.5 μg of oligo dT primer were mixed in 7 μl of water, incubated for 5 min at 70°C and subsequently at 42°C for about 3 min. The following components were added to 5 μl of said reaction mixture: 4 μl reaction buffer (5 x) for SuperScript II reverse transcriptase (Invitrogen), 2 μl dTTP (2 mM), 2 μl dATP, dGTP, dCTP (5 mM), 2 μl DTT (100 mM), 2.5 μl RNasin (40 U, Promega) and 2 μl FluoriLink Cy3-dUTP (1 mM) or 2 μl FluoriLink Cy5-dUTP (1 mM, Amersham Biosciences) respectively, and 1 μl SuperScript II reverse transcriptase (200 U, Invitrogen) to result in a total of 19.5 μl. The mixture was incubated for 1 h at 42°C. After addition of further 200 U SuperScript II reverse transcriptase the mixture was incubated for another 1 h at 42°C. 7 μl of 0.5 M NaOH/50 mM EDTA were added and the mixture was incubated at 70°C for 15 min. The reaction mixture was neutralised by addition of 10 μl Tris-HCl pH 7.5 (1 M). The labelled cDNA of the two corresponding samples were pooled and purified with Qiaquick purification columns (Qiagen) according to the manufacturer's protocol.
6. Chip hybridisation and set-up of microarrays
The cDNA microarrays used for this study were Hyper Gene Yeast Chips from Hitachi Software Engineering Europe AG. According to the manufacturer, about 0.1 to 0.3 ng of PCR amplified cDNA (approximately 200 bp to 8000 bp) were spotted onto a poly-L-lysine coated glass slide and fixed by baking, succinic anhydride blocking and heat denaturation.
Labelled cDNA was resuspended in about 70 μl of 5 × SSC/0.05% SDS, heat denatured at 95°C for 3 min and cooled on ice. SDS crystals appearing were dissolved by short and slight warming and the mixture was gently applied to a Yeast Chip according to the scheme presented in table 1. The spotted area was covered with a cover glass and the chips were placed in an airtight container with a humidified atmosphere at 60°C for 16 h.
The cover glasses were removed in 2 × SSC/0.1% SDS and the chips were washed consecutively for 5–10 min each in 2 × SSC/0.1% SDS, 0.5 × SSC/0.1% SDS, and 0.2 × SSC/0.1% SDS at RT. The chips were centrifuged at 600 rpm for 3 min in order to dry them. The washing conditions were chosen according to the manufacturer's manual. We have tested less stringent washing conditions which led to higher background without increasing the number of positive signals.
7. Data acquisition and processing
Images were scanned at a resolution of 50 μm with a G2565AA Microarray scanner (Agilent) and were imported into the GenePix Pro 4.1 (Axon Instruments) microarray analysis software. GenePix Pro 4.1 was used for the quantification of the spot intensities. Each appearing gene spot was averaged. The data set was then imported into GeneSpring 6.1 (Silicon Genetics) for further normalisation and data analysis.
All of the values of each channel on each chip were divided by their respective median for normalisation. Subsequently, the median intensity of all 84 TE spots (spotted with buffer, no DNA) deduced from each value, and all spot values less then the standard deviation of said 84 threshold values were considered to be not significant and were set to the value of the standard deviation. To determine induction or repression of gene activity, the normalised signals on each spot were compared, and all genes showing a signal difference exceeding the threshold (2 fold for S. cerevisiae, and 1.5 fold for P. pastoris, see results) on both parallel independent microarrays were judged as significantly regulated.
8. Statistical evaluation of microarray data
After normalisation and background deduction, pairwise correlations of all significant values were calculated using Pearson's correlation coefficient. To evaluate the variability of data derived from both dyes on one chip, the standard deviations of all significant spots hybridised with two identical samples were plotted against the respective normalised mean intensity value. To judge the correlation of gene regulation between S. cerevisiae and P. pastoris, the regulation factors of all of genes that were significantly downregulated in S. cerevisiae upon a difference of pH 5.0 to 3.5, were correlated to the respective P. pastoris regulation factor upon the same media difference, using the Pearson's correlation coefficient.
The significance of all correlations against randomly distributed values were evaluated by a t-test, applying a significance level p < 0.01. To exclude an effect of data clustering (as the majority of the values are rather low) on correlation, Spearman's correlation coefficients were calculated as well. As these differed only slightly from Pearson's coefficients, they are not shown.
Linear regression analysis was performed with the regulation intensities of P. pastoris against S. cerevisiae in order to compare the average fold change observed for both yeasts.
9. Determination of the intracellular pH (pHi)
The pHi was determined as described by Valli et al. . Essentially, samples were centrifuged and resuspended in McIlvaine buffer  at pH 3.0, containing 20 μM carboxy SNARF-4F AM (Molecular Probes). Loaded cells were analysed on a FACS Calibur (Becton Dickinson, Franklin Lakes, NJ USA) with a 488 nm argon-ion laser. 104 cells were measured per analysis, using PBS as the sheath fluid. Carboxy SNARF-4F fluorescence emission was measured through a 585/21 BP filter (FL2) and a 670 LP filter (FL3). Threshold settings were adjusted so that cell debris were excluded from data acquisition. The ratio of the two fluorescence intensities is a measure for the internal pH. Calibration was performed with amphotericin B (Sigma) perforated cells as described in Valli et al. .
10. Northern blot analysis
Northern blot analysis was essentially performed as described by Sambrook et al. . In short, total RNA prepared as described above was fractionated on a denaturing formaldehyde containing gel, capillary blotted onto a nylon membrane (Nytran Supercharge, Schleicher & Schuell) and fixed by baking. The membrane was stained with methylene blue (0.04% in 0.5 M NaOAc, pH 5.2) for quality control and to ensure that equal amounts of RNA had been loaded.
The probes were PCR amplified from genomic P. pastoris DNA using the following primers: actin: gttccagccttctacgtttctattca and acggagtactttctttctggtggag; SAH: agctgaacttgattttggacgac and acttgaggcttgatgttgctgac; Met17: tgcatcaatggtcacggtaaca and tggtgagtagagtagtaaggagcaatga. The probe for human trypsinogen was prepared as described in . The probes were DIG labelled using the PCR DIG Labeling Mix (Roche) according to the manufacturer's protocol.
Pre-hybridisation and hybridisation were performed in high SDS hybridisation buffer at 42°C.
The blots were washed twice at RT with 2 × SSC/0.1 % SDS and two times at 68°C with 0.5 × SSC/0.1 % SDS. Staining of the blots was performed using anti-Digoxigenin-alkaline phosphatase Fab Fragments (Roche) and the CDP Star chemiluminescent reagent (Tropix) according to the manufacturer's protocol. The images were taken with a Lumi imager F1 (Boehringer Mannheim).
Cereghino JL, Cregg JM: Heterologous protein expression in the methylotrophic yeast Pichia pastoris. FEMS Microbiol Rev. 2000, 24: 45-66.
Porro D, Mattanovich D: Recombinant protein production in yeasts. Recombinant Gene Expression: Reviews and Protocols. Edited by: Balbas P, Lorence A. 2004, 241-258. Humana Press Inc., Totawa, NJ, USA
Rio RVM, Lefevre C, Heddi A, Aksoy S: Comparative Genomics of Insect-Symbiotic bacteria: Influence of Host Environment on Microbial Genome Composition. Appl Environ Microbiol. 2003, 69: 6825-6832.
Schoondermark-Stolk SA, ter Schure EG, Verrips CT, Verkleij AJ, Boonstra J: Identification of salt-induced genes of Zygosaccharomyces rouxii by using Saccharomyces cerevisiae Gene Filters®. FEMS Yeast Res. 2002, 2: 525-532.
Becher M, Talke IN, Krall L, Krämer U: Cross-species microarray transcript profiling reveals high constitutive expression of metal homeostasis genes in the shoots of the zinc hyperaccumulator Arabidopsis halleri. The Plant Journal. 2004, 37: 251-268.
Hittel D, Storey KB: Differential expression of adipose- and heart-type fatty acid binding proteins in hibernating ground squirrels. Biochim Biophys Acta. 2001, 1522: 238-243.
Hogstrand C, Balesaria S, Glover CN: Application of genomics and proteomics for study of the integrated response to zinc exposure in a non-model fish species, the rainbow trout. Comp Biochem Physiol B Biochem Mol Biol. 2002, 133: 523-535.
Huang GS, Yang SM, Hong MY, Yang PC, Liu YC: Differential gene expression of livers from ApoE deficient mice. Life Sciences. 2000, 68: 19-28.
Renn SC, Aubin-Horth N, Hofmann HA: Biologically meaningful expression profiling across species using heterologous hybridization to a cDNA microarray. BMC Genomics. 2004, 5: 42-
Chismar JD, Mondala T, Fox HS, Roberts E, Langford D, Masliah E, Salomon DR, Head SR: Analysis of result variability from high-density oligonucleotide arrays comparing same-species and cross-species hybridisations. Biotechniques. 2002, 33: 516-518. 520, 522 passim.
Moody DE, Zou Z, McIntyre L: Cross-species hybridisation of pig RNA to human nylon microarrays. BMC Genomics. 2002, 3: 27-
Kurtzman CP, Robnett CJ: Identification and phylogeny of ascomycetous yeasts from analysis of nuclear large subunit (26S) ribosomal DNA partial sequences. Antonie Van Leeuwenhoek. 1998, 73: 331-371.
Wegner GH, Harder W: Methylotrophic yeasts. Antonie Van Leeuwenhoek. 1986, 53: 29-36. 10.1007/BF00422632.
Mattanovich D, Gasser B, Hohenblum H, Sauer M: Stress in recombinant protein producing yeasts. J Biotechnol. 2004, 113: 121-135.
Hohenblum H, Gasser B, Maurer M, Borth N, Mattanovich D: Effects of gene dosage, promoters and substrates on unfolded protein stress of recombinant Pichia pastoris. Biotechnol Bioeng. 2004, 85: 367-375.
Hohenblum H, Borth N, Mattanovich D: Assessing viability and cell-associated product of recombinant protein producing Pichia pastoris with flow cytometry. J Biotechnol. 2003, 102: 281-290.
Rodriguez-Navarro S, Llorente B, Rodriguez-Manzaneque MT, Ramne A, Uber G, Marchesan D, Dujon B, Herrero E, Sunnerhagen P, Perez-Ortin JE: Functional analysis of yeast gene families involved in metabolism of vitamins B1 and B6. Yeast. 2002, 19: 1261-1276.
Zeidler J, Sayer BG, Spenser ID: Biosynthesis of vitamin B1 in yeast. Derivation of the pyrimidine unit from pyridoxine and histidine. Intermediacy of urocanic acid. J Am Chem Soc. 2003, 125: 13094-13105.
Valli M, Sauer M, Branduardi P, Borth N, Porro D, Mattanovich D: Intracellular pH distribution in Saccharomyces cerevisiae cell populations analyzed by flow cytometry. Appl Environ Microbiol.
Imai T, Ohno T: Measurement of yeast intracellular pH by image processing and the change it undergoes during growth phase. J Biotechnol. 1995, 38: 165-172.
Hohenblum H, Naschberger S, Weik R, Katinger H, Mattanovich D: Production of recombinant human trypsinogen in Escherichia coli and Pichia pastoris. A comparison of expression systems. In Recombinant protein production with prokaryotic and eukaryotic cells. A comparative view on host physiology. Edited by: Merten OW, Mattanovich D, Lang C, Larsson G, Neubauer P, Porro D, Postma P, Teixeira de Mattos J, Cole JA. 2001, 339-346. Kluwer Acad Publ, Dortrecht NL,
Van Dijken JP, Bauer J, Brambilla L, Duboc P, Francois JM, Gancedo C, Giuseppin ML, Heijnen JJ, Hoare M, Lange HC, Madden EA, Niederberger P, Nielsen J, Parrou JL, Petit T, Porro D, Reuss M, van Riel N, Rizzi M, Steensma HY, Verrips CT, Vindelov J, Pronk JT: An interlaboratory comparison of physiological and genetic properties of four Saccharomyces cerevisiae strains. Enzyme Microb Technol. 2000, 26: 706-714.
McIlvaine TC: A Buffer Solution for Colorimetric Comparison. J Biol Chem. 1921, 49: 183-186.
Sambrook J, Fritsch EF, Maniatis T: Molecular cloning: a laboratory manual. Edited by: Sambrook J, Russell DW. 2001, Cold Spring Harbor, NY: Cold Spring Harbor Laboratory Press
The authors thank Prof. Harald Strelec (Institute of Applied Statistics and Computing, Univ. Nat. Res. Appl. Life Sci. Vienna) for valuable support in the statistical analyses. Thomas Öfferl helped with data conversion and normalisation, and Ksenija Lopandic verified the identity of the P. pastoris strain with 26S sequencing. MV received an Ernst Mach Grant from the Austrian Federal Ministry of Education, Science and Culture.
MS and PB designed and performed the microarray hybridisation experiments. MS and BG analysed and interpreted the microarray data, and drafted the manuscript. MV performed the pHi determinations. MM ran and analysed the fed batch fermentations. DP participated in the design of this study, and in data interpretation. DM participated in the design of this study, and in data interpretation, performed the statistical analyses, and drafted part of the manuscript. All authors read and approved the final manuscript.
About this article
Cite this article
Sauer, M., Branduardi, P., Gasser, B. et al. Differential gene expression in recombinant Pichia pastoris analysed by heterologous DNA microarray hybridisation. Microb Cell Fact 3, 17 (2004) doi:10.1186/1475-2859-3-17
- Significant Spot
- Methanol Utilisation
- Lower Specific Growth Rate
- Methanol Metabolism
- Heterologous Hybridisation