Skip to main content

Effective enhancement of Pseudomonas stutzeri D-phenylglycine aminotransferase functional expression in Pichia pastoris by co-expressing Escherichia coli GroEL-GroES

Abstract

Background

D-phenylglycine aminotransferase (D-PhgAT) of Pseudomonas stutzeri ST-201 catalyzes the reversible stereo-inverting transamination potentially useful in the application for synthesis of D-phenylglycine and D-4-hydroxyphenylglycine using L-glutamate as a low cost amino donor substrate in one single step. The enzyme is a relatively hydrophobic homodimeric intracellular protein difficult to express in the soluble functionally active form. Over-expression of the dpgA gene in E. coli resulted in the majority of the D-PhgAT aggregated into insoluble inclusion bodies that failed to be re-natured. Expression in Pichia pastoris was explored as an alternative route for high level production of the D-PhgAT.

Results

Intracellular expression of the codon-optimized synthetic dpgA gene under the P AOX1 promoter in P. pastoris resulted in inactive D-PhgAT associated with insoluble cellular fraction and very low level of D-PhgAT activity in the soluble fraction. Manipulation of culture conditions such as addition of sorbitol to induce intracellular accumulation of osmolytes, addition of benzyl alcohol to induce chaperone expression, or lowering incubation temperature to slow down protein expression and folding rates all failed to increase the active D-PhgAT yield. Co-expression of E. coli chaperonins GroEL-GroES with the D-PhgAT dramatically improved the soluble active enzyme production. Increasing gene dosage of both the dpgA and those of the chaperones further increased functional D-PhgAT yield up to 14400-fold higher than when the dpgA was expressed alone. Optimization of cultivation condition further increased D-PhgAT activity yield from the best co-expressing strain by 1.2-fold.

Conclusions

This is the first report on the use of bacterial chaperones co-expressions to enhance functional intracellular expression of bacterial enzyme in P. pastoris. Only two bacterial chaperone genes groEL and groES were sufficient for dramatic enhancement of functionally active D-PhgAT expression in this yeast. With the optimized gene dosage and chaperone combinations, P. pastoris can be attractive for intracellular expression of bacterial proteins since it can grow to a very high cell density which is translated into the higher volumetric product yield than the E. coli or other bacterial systems.

Background

The D-phenylglycine aminotransferase (D-PhgAT) from a soil bacterium Pseudomonas stutzeri ST-201 [1], catalyzes the reversible transamination specific for D-phenylglycine or D-4-hydroxyphenylglycine in which 2-oxoglutarate is an amino-group acceptor that are converted into benzoylformate or 4-hydroxybenzoylformate and L-glutamate (Figure 1). Both D-phenylglycine and D-4-hydroxyphenylglycine are important side chain moieties in high demand for production of semisynthetic penicillin and cephalosporin antibiotics such as ampicillin, amoxicillin, cephalexine and cephadroxyl. Currently, D-phenylglycine and D-4-hydroxyphenylglycine are industrially produced by a process using two enzymes, the hydantoinase and carbamoylase [2]. However, the reaction rates are low since the solubilities of the substrates, (D,L) phenylhydantoin and (D,L)-4-hydroxyphenylhydantoin, are very poor. Alternatively, a single-step enzymatic synthesis using a D-amino acid aminotransferase is possible. But known D-amino acid aminotransferases have very low transamination activity towards D-phenylglycine [3] and they accept only D-amino acids as the amino-group donors. Due to the high cost of D-amino acids (such as D-alanine, D-glutamic acid), their direct application as amino-group donors is impractical. Using an L-amino acid (such as L-alanine or L-glutamic acid) together with an amino acid racemase to convert it to the corresponding D-amino acid to serve as the amino-group donor for the D-amino acid aminotransferase will increase the production cost. Additionally, the racemase may interfere with the transamination reaction. By contrast, with the D-PhgAT, due to its characteristic “stereo-inverting” transamination activity, a low cost substrate L-glutamic acid can be used as an amino-group donor for the synthesis of enantiomerically pure D-phenylglycine or D-4-hydroxyphenylglycine in a single transamination step without the need for any amino acid racemase [1].

Figure 1
figure 1

Stereo-inverting aminotransferase reaction catalyzed by D-PhgAT from Pseudomanas stutzeri ST-201. The enzyme reversibly transfers the amino group between L-glutamic acid and D-phenylglycine which have opposite stereochemistry.

Before enzymatic synthesis of D-phenylglycine and D-4-hydroxyphenylglycine using D-PhgAT can be further developed, a large supply of the enzyme should be established. Initially, the conventional method using commercially available gene expression systems for over-production of the D-PhgAT in E. coli resulted in the formation of inclusion body and very low amount of the soluble functional enzyme was obtained [unpublished observations]. The attempt to solubilize the insoluble enzyme aggregates and refold the protein, using a published method [4], to the functional D-PhgAT was not successful.

It is well-known that Pichia pastoris protein expression system offers various advantages [57] including the success in high level production of a variety of heterologous proteins both intra- and extracellularly, the ability of the host to grow to very high cell density using simple culture media, and the availability of powerful genetic manipulation techniques. Several approaches for improving the solubility and expression level of recombinant protein in P. pastoris have been reported, for instance, low-temperature expression [8, 9], adjusting of media composition [10, 11], modifying the host strains [12, 13], fine-tuned gene expression by generating promoter mutants [14], rational site-directed mutagenesis [15, 16], directed evolution [17, 18], translational fusion proteins [1922], co-expression of chaperones [2326], codon optimization [27, 28] and creating the multiple gene copy number [2931]. The beneficial characteristics and the documented successful applications encouraged us to exploit the P. pastoris protein expression system for production of soluble active D-PhgAT at high yield.

Results

Intracellular expression of D-PhgAT in P. pastoris KM71

Levels of D-PhgAT production from P. pastoris KM71 clones harboring 3 copies of wild-type and codon-optimized dpgA genes under the AOX1 promoter were compared. Expression from the codon-optimized dpgA gene yielded high amount of D-PhgAT protein (Figure 2A) with low level of D-PhgAT activity (Table 1, strain KM_AT3). By contrast, expression from wild-type dpgA gene resulted in much lower amount of D-PhgAT protein and no D-PhgAT activity was detectable.

Figure 2
figure 2

Expression of D-PhgAT in P. pastoris KM71. SDS-PAGE analysis of total cellular proteins of (a) P. pastoris KM71 expressing wild-type and codon-optimized dpgA genes under the control of AOX1 promoter at 30°C for 24 h. Lane M, molecular mass markers; Lane 1, P. pastoris KM71 harboring the parent vector pPIC3.5 K; Lane 2, P. pastoris strain KM_AT3 (see Table 1) expressing D-PhgAT from the codon-optimized dpgA gene; Lane 3–5, three P. pastoris clones expressing D-PhgAT from the wild-type dpgA gene. (b) Lane 2–7, P. pastoris KM_AT3 after induction at 30°C for 24, 48, 72, 96, 120 and 144 h, respectively. The arrow indicates protein bands of the D-PhgAT (45 kDa).

Table 1 Copy number of dpgA and groEL-groES genes and D-PhgAT activity of different P. pastoris clones

The codon-optimized synthetic dpgA gene under the control of the AOX1 promoter of the pPIC3.5 K plasmid was integrated into the HIS4 locus on the chromosome of the P. pastoris KM71 host. The clone harboring 3 copies of the dpgA gene was induced with 0.5% methanol for gene expression at 30°C for 144 h to determine the D-PhgAT yield and the optimal time for product harvesting. The D-PhgAT was strongly expressed constituting up to 30% of total cellular proteins after 24 h of induction and remained at this level until 144 h (Figure 2B). However, majority of the expressed D-PhgAT associated with the insoluble cellular fraction (Figure 3) as inactive enzyme. Soluble protein fraction was found to contain D-PhgAT enzymatic activity at 0.0054 U·mg-1 (Table 1). Several strategies known to promote native folding of the over-expressed proteins including lower temperature, increased intracellular concentrations of osmolytes and molecular chaperones [32] were attempted in this study. By using 0.5 M sorbitol, 0.4 to 4 mM benzyl alcohol, and 20°C incubation temperature; the yield of soluble active D-PhgAT was not significantly enhanced as judged from the intensity of protein bands (Figure 4).

Figure 3
figure 3

P. pastoris KM71 expressed D-PhgAT as insoluble protein. SDS-PAGE analysis of soluble (S) and insoluble (I) protein fractions of P. pastoris KM71 expressing D-PhgAT under the control of AOX1 promoter after induction at 30°C for 24 h. Lane M, molecular mass markers. The arrow indicates protein band of the D-PhgAT (45 kDa).

Figure 4
figure 4

Effect of temperature and benzyl alcohol (BA) on soluble D-PhgAT production. SDS-PAGE analysis of soluble (S) and insoluble (I) protein fractions from P. pastoris KM71 expressing D-PhgAT under the control of AOX1 promoter after induction for 24 h at 30°C, 25°C, and at 20°C without and with 0.4 mM benzyl alcohol added to the culture. Lane M, molecular mass markers. The arrow indicates protein bands of D-PhgAT.

Co-expression of GroEL-GroES chaperones with D-PhgAT in P. pastoris KM71

The pAO815 plasmid containing the dpgA gene under the control of AOX1 promoter and the groEL and groES genes each under the control of an AOX1 promoter (pAO_D-PhgAT_AOX_ELS) or a GAP promoter (pAO_D-PhgAT_GAP_ELS) were constructed [see Additional file 1]. After transformation and gene integration into the P. pastoris KM71 chromosome, it was found that co-expression of GroEL-GroES molecular chaperones with D-PhgAT at 30°C yielded functionally active enzyme with the highest activity at 24 h after induction. Clone harboring pAO_D-PhgAT_GAP_ELS yielded slightly higher D-PhgAT activity than that with pAO_D-PhgAT_AOX_ELS (Figure 5). Noticeably, D-PhgAT activity declined after 48 h and slightly increased after 72 h. Viable cell count showed the decrease in number of viable cells at 48 h and increase at 72 h correlated well with the D-PhgAT activity profile. SDS-PAGE analysis of cellular proteins revealed substantial amounts of D-PhgAT protein in the soluble protein fractions concomitant with its absence from the insoluble fractions (Figure 6).

Figure 5
figure 5

D-PhgAT activity from P. pastoris KM71 co-expressing groEL and groES with dpgA. D-PhgAT activity in cell extract and viable cell counts of P . pastoris KM71 integrated with pAO_D-PhgAT_AOX_ELS plasmid (white circle, white triangle) or pAO_D-PhgAT_GAP_ELS (filled circle, filled triangle) during induction with 0.5% methanol at 30°C for 72 h. Solid line, specific activity; dash line, volumetric activity; please see Table 1 for definitions.

Figure 6
figure 6

SDS-PAGE analysis of soluble (S) and insoluble (I) protein fractions from P. pastoris KM71 expressing D-PhgAT alone and with GroEL-GroES co-expression. Lane M, molecular mass markers; pAO, clone with blank pAO815; pAO_AT, clone expressing dpgA under P AOX1 ; pAO_AT_AOX_ELS, clone expressing P AOX1 dpgA with co-expressing P AOX1 groEL and P AOX1 groES; pAO_AT_GAP_ELS, clone expressing P AOX1 dpgA with co-expressing P GAP groEL and P GAP groES. The protein bands corresponding to D-PhgAT (45 kDa) and GroEL (60 kDa) are arrow indicated.

Expression of multiple copies of dpgA, groEL and groES genes in P. pastoris KM71

The P. pastoris KM71 chromosomally harboring at the HIS4 locus 3 copies of the dpgA gene under the control of P AOX1 after transformation with pPIC3.5K_D-PhgAT plasmid was used as the host for co-expression with multiple copies of the groEL and groES genes. The pPICZ_26S rDNA_GAP_GroELS [see Additional file 2] was constructed to express the P GAP groEL and P GAP groES that could be integrated in multiple copies at either the 5AOX1 or the 26S rDNA sites of the Pichia chromosome. After screening the transformants on YPD plates containing zeocin, two clones from 5AOX1 integration and two clones from 26S rDNA integration experiments showed resistance to 5000 μg·mL-1 of zeocin. Quantitative real time PCR analysis of gene copy number revealed that clones obtained from 5AOX1 integration contained 3 and 4 copies, while clones from 26S rDNA integration contained 2 and 10 copies of the groEL-groES genes, repectively. D-PhgAT expressions of these clones were performed at 30°C in culture medium containing 0.5% methanol for 24 h. Compared with strain containing single copies of the dpgA and groEL-groES genes (KM_AT1_ELS1), clones with multiple copies yielded approximately 1.5 times (KM_AT3_ELS2) to 5.5 times (KM_AT3_ELS10) more of D-PhgAT volumetric activity. The D-PhgAT volumetric activity from clone co-expressing 10 copies of groEL-groES was 14400 times higher than the clone expressing dpgA alone (Table 1). SDS-PAGE analyses comparing D-PhgAT expressions from different P. pastoris KM71 strains constructed in the present study are shown in Figure 7. The amounts of D-PhgAT protein in the soluble fractions of cellular protein extracts correlated well with the D-PhgAT enzymatic activity summarized in Table 1. And less amounts of insoluble D-PhgAT protein were formed as the copy number of the co-expressing groEL-groES genes increased.

Figure 7
figure 7

Comparison of D-PhgAT expressions from P. pastoris KM71 strains carrying different copy numbers of dpgA and groEL-groES genes. SDS-PAGE analysis of soluble (a) and insoluble (b) fractions from 6 recombinant strains. Lane M, molecular mass markers; Lane 1, strain KM_AT3; Lane 2; strain KM_AT1_ELS1; Lane 3–6; strains KM_AT3_ELS3, KM_AT3_ELS4, KM_AT3_ELS2, KM_AT3_ELS10, respectively. Please see Table 1 for details of each strain. The protein bands corresponding to D-PhgAT (45 kDa) and GroEL (60 kDa) are arrow indicated.

Effect of cultivation conditions on soluble active D-PhgAT yield in P. pastoris KM_AT3_ELS10

As the highest yield of soluble active D-PhgAT was obtained in the P. pastoris KM_AT3_ELS10 which contained 3 copies of the dpgA gene and 10 copies of the groEL-groES genes, optimization of the cultivation conditions was done on this final co-expressing strain to see if the active D-PhgAT yield could be further increased. The KM_AT3_ELS10 was cultivated under various conditions known to promote the native protein folding including addition of 0.5 M sorbitol, 0.4 mM benzyl alcohol and lowering the incubation temperatures to 25°C and 20°C. At 24 h of induction with 0.5% methanol, cells were collected and the levels of D-PhgAT protein and enzymatic activity were analyzed. As shown in Table 2, lowering the cultivation temperature from 30°C to 25°C resulted in higher D-PhgAT activity yields but further decreasing the temperature to 20°C deteriorated the activity yields to lower than those at 30°C. Addition of 0.5 M sorbitol or 0.4 mM benzyl alcohol or both, impaired the D-PhgAT activity yields at all three temperatures tested. The strongest negative effects were observed when both additives were present. The best specific and volumetric D-PhgAT activity yields of 72.7 U·mg-1 and 50512 U·L-1, respectively, were obtained when the cultivation temperature was 25°C and without additives. SDS-PAGE analysis of proteins in the soluble and insoluble protein fractions of cells cultivated under the above conditions showed the amount of D-PhgAT protein (Figure 8) in good agreement with the D-PhgAT activity detected (Table 2).

Table 2 Effects of cultivation conditions on D-PhgAT yield from P. pastoris strain KM_AT3_ELS10
Figure 8
figure 8

Comparison of D-PhgAT expressions from P. pastoris KM_AT3_ELS10 cultivated under different conditions for 24 h. SDS-PAGE analysis of soluble and insoluble protein fractions of the cultures induced at 30°C (a), 25°C (b) and 20°C (c), respectively, without and with 0.5 M sorbitol or 0.4 mM benzyl alcohol or both added. Lane M, molecular mass markers; the protein bands corresponding to D-PhgAT (45 kDa) are arrow indicated.

Purification of recombinant D-PhgAT using immobilized metal ion affinity chromatography

The D-PhgAT was purified from the clarified cell lysates by His tag-mediated affinity chromatography. Protein elution profile during purification is shown in Figure 9A. The unbound proteins were washed out with 45 mL of binding buffer and peak of unrelated proteins was eluted with early imidazole gradient. The D-PhgAT was eluted in a large symmetrical peak well-separated from other host proteins at around 35 mM imidazole. SDS-PAGE analysis of active fractions collected from this peak showed that the D-PhgAT was purified to near homogeneity (Figure 9B). The process brought about 5.2-fold purification and 76.6% yield in one single step. After concentration, the enzyme solution consisting of pure D-PhgAT (Figure 9C) had a specific activity of 888.6 U·mg-1.

Figure 9
figure 9

Purification of the C-terminally 6xHis-tagged D-PhgAT by affinity chromotagraphy. (a) Protein elution profile of D-PhgAT purification from cell-free extract by immobilized ion affinity chromatography; (b) SDS-PAGE analysis of eight 3 mL active fractions collected during the elution volume of 130–154 mL showing purity and amount of D-PhgAT (45 kDa) obtained; (c) SDS-PAGE analysis of proteins in cell-free extract (Lane 1), unbound fraction (Lane 2), weakly bound fraction (Lane 3), and the purified concentrated D-PhgAT (Lane 4). Lane M, molecular mass markers.

Discussion

The methylotrophic yeast Pichia pastoris has been developed for heterologous protein expression offering several advantages over other eukaryotic or prokaryotic systems including the high levels expression of intracellular and secreted proteins in the range of grams per liter using the strong inducible P AOX promoter or the strong constitutive P GAP promoter, the ability to grow at high cell-density, the simple scale up and well-developed fermentation processes [8, 3335]. Since P. pastoris has eukaryotic posttranslational modification machinery which can process the expressed protein similar to higher eukaryotes, it is usually a system of choice for expression of eukaryotic proteins which require proper posttranslational modifications for their functions. Thus, so far there are only a few reports that exploit the benefits of the P. pastoris system for the high level expression of bacterial proteins, especially the intracellular ones.

In our case, the Pseudomonas D-PhgAT which is a relatively hydrophobic homodimeric intracellular enzyme [1] has been shown to be difficult to express in the regular E. coli expression system. We thus explored the possibility of using the P. pastoris system as an alternative approach for expressing this problematic enzyme. Initially, the dpgA gene encoding the D-PhgAT was expressed under the strong inducible promoter AOX1 both intracellularly, and extracellularly by fusion with the alpha-factor signal peptide. The extracellular expression resulted in no D-PhgAT protein or enzymatic activity, neither in culture medium nor in cell extract (data not shown). For intracellular expression, the D-PhgAT was highly produced at up to 30% of total cellular proteins but as the inactive enzyme in the insoluble cellular fraction. Noticeably, very low level of D-PhgAT activity could be detected in the cell extracts indicating that functional expression of D-PhgAT in this host is possible which encouraged us to further pursue system optimization. Addition of sorbitol to the culture medium at a high concentration (0.5 M) to force the Pichia cells to accumulate viscous intracellular osmolytes (such as glycerol) which slow down the rates of protein structure acquisition and might enhance native folding of the enzyme [32, 36, 37] yielded no detectable D-PhgAT activity. The reason for this failure may be because intracellular glycerol accumulation in response to osmotic stress might repress the AOX1 promoter in spite of the presence of methanol as an inducer [3840]. Likewise, addition of benzyl alcohol at 0.4 – 4 mM as a membrane fluidizing heat shock response inducing agent for inducing the synthesis of intracellular molecular chaperones that would assist protein folding [32, 41] was found to be ineffective and all the expressed D-PhgAT was nonfunctional and associated with insoluble cellular fraction. Decreasing the incubation temperature to 20°C to slow down the rates of protein translation and folding could not increase the formation of soluble active D-PhgAT.

As all the simple approaches mentioned above failed, we attempted a more sophisticated method by co-expression with molecular chaperones. D-PhgAT is an enzyme of a Gram-negative bacterium. We hypothesized that if we co-expressed functional E. coli chaperones (whose expression plasmids are commercially available) in P. pastoris the chaperones would assist native folding of the D-PhgAT. Without codon optimization, two genes encoding the E. coli GroEL-GroES chaperonin system were co-expressed intracellularly under the strong inducible P AOX1 or the strong constitutive P GAP with the P AOX1 dpgA, each as a single copy gene, in P. pastoris. Interestingly, substantial amount of soluble D-PhgAT was produced and ca 2600-fold increased in volumetric activity could be measured, compared with the system without chaperone co-expression (Figures 4, 6 and Table 1). Co-expression of groEL and groES under the constitutive promoter P GAP yielded slightly more active D-PhgAT than with the inducible promoter P AOX1 suggesting that constitutive expression of molecular chaperones prior to the strong induction of D-PhgAT expression could be more effective in promoting native protein folding. Increasing gene dosage of the dpgA and those of the groEL and groES progressively increased the D-PhgAT activity yield (Table 1). It was obvious that chaperones gene were required in a higher copy numbers than the dpgA gene. The highest gene dosage that could be integrated into the chromosome of the P. pastoris host in the present study was 3 copies of the dpgA and 10 copies each of the groEL and groES which could increase the D-PhgAT yield up to 14400-fold higher than with 3 copies of the dpgA expressed without chaperone co-expression. It is likely that gene dosage for maximum D-PhgAT yield for this system had not been reached and yet remains to be determined. Co-expression of additional chaperone(s) in various combinations should also be investigated.

Conclusions

To the best of our knowledge, this is the first report on the use of bacterial chaperone (specifically the E. coli GroEL-GroES) co-expression to enhance functional expression of a difficult-to-express bacterial enzyme in P. pastoris. The interesting point is that only two bacterial chaperone genes were sufficient to dramatically enhance functional expression of a bacterial enzyme in this host. The P. pastoris system is attractive for intracellular expression of bacterial proteins because the organism can be cultured in a very high cell density. With the optimized gene expression this could be translated into a higher volumetric product yield than the bacterial systems such as E. coli. Additionally, compared with plasmid-based expression in bacteria, chromosomally integrated recombinant gene in P. pastoris can be far more stably expressed in continuous and large-scale fermentation process without the need for antibiotic selection [6].

Methods

Strains, plasmids, oligonucleotides, media, chemicals

The E. coli DH5α and P. pastoris KM71 were obtained from Novagen (Madison, WI, USA) and Invitrogen (San Diego, CA, USA), respectively. The Pichia expression plasmids pPIC3.5 K, pAO815, pGAPZ B and pPICZ B were purchased from Invitrogen. The pGro7 was purchased from Takara Bio Inc (Japan). The pPICZ_26S rDNA was constructed and provided by Prof. W. Panbangred (Mahidol University, Thailand). The pBPL-ph plasmid harboring the wild-type dpgA gene was obtained from our previous study [42]. The dpgA gene was codon-optimized for expression in Pichia host, and synthesized by GenScript (Piscataway, NJ, USA) [see Additional file 3. Primers for gene amplification and real-time PCR are shown in Table 3. Restriction endonucleases, DNA polymerase and T4 DNA ligase were supplied by New England Biolabs (Ipswich, MA, USA). Culture media for bacteria and yeast cultivation: Luria-Bertani (LB), Yeast Extract-Peptone-Dextrose (YPD), buffered complex glycerol (BMGY), buffered complex methanol (BMMY) and Minimal Dextrose (MD) were from Becton, Dickinson & Co. (NJ, USA). The antibiotics ampicillin and zeocin were from Bio Basic (Ontario, Canada) and Invitrogen, respectively. Methanol and all other chemicals were obtained from Sigma (St. Louis, MO, USA).

Table 3 Primers used in PCR and DNA sequencing reactions. F: forward primer, R: reverse primer, underlined: restriction endonuclease site

Generation of Pichia pastoris strain expressing intracellularly recombinant D-PhgAT

Wild-type dpgA gene was amplified from the pBPL-ph plasmid using the Pfu DNA polymerase with the FwtdpgA and RwtdpgA primers containing Bam HI and Eco RI sites, respectively. Cloning of the wild-type dpgA gene into the Pichia expression plasmid pPIC3.5K, transformation into P. pastoris KM71, and selection of integrant clones were performed in the same manners as for the P. pastoris codon-optimized synthetic dpgA gene described below.

The synthetic dpgA gene in the pUC57_D-PhgAT plasmid obtained from GenScript was PCR amplified using the Pfu DNA polymerase with the forward and reverse primers FdpgA _3.5 K and RdpgA _3.5 K (Table 3) having Bam HI and Eco RI sites, respectively. The PCR product was digested and cloned into the corresponding sites of the Pichia expression vector pPIC3.5 K yielding the pPIC3.5K_D-PhgAT which was subsequently transformed into E. coli DH5α. The pPIC3.5K_D-PhgAT plasmid extracted from E. coli DH5α was linearized with Sal I and 10 μg of the DNA was mixed with 80 μL of competent P. pastoris KM71 cell suspension. Transformation by electroporation was carried out at 1.5 kV, 25 μF and 200 Ω (Gene Pulser II (Bio-Rad). The transformants were selected on minimal dextrose (MD) without histidine (1.34% YNB with ammonium sulphate without amino acids, 4 x 10-5% biotin, and 2% dextrose) agar plates. Two mL of sterile water was spread over the His+ transformants on each MD plate to resuspend the transformants. Cell suspensions from all plates were pooled and transferred into a sterile, 50 mL conical centrifuge tube, and vortexed briefly for 5–10 seconds. The cell density was determined using a spectrophotometer (1 OD600nm = 5 x 107 cells·mL-1). The 10-5, 10-6 and 10-7 dilutions of the pooled transformants were prepared using sterile water and 200 μL aliquots were plated on YPD agar containing Geneticin at final concentration of 250, 500, 750 and 1000 μg·mL-1. All plates were incubated at 30°C and examined daily to select for the strains containing multiple copies of the dpgA gene. The integration of the dpgA gene into the chromosome of selected Pichia transformants was verified by PCR using gene specific primers (FdpgA _3.5 K and RdpgA _3.5 K, Table 3). The verified clone with the highest D-PhgAT expression level as judged from the enzyme activity was subjected to DNA sequencing to check for the correctness of the integrated dpgA gene before it was utilized in this study. Genomic DNA was isolated from the selected P. pastoris clones. The integrated DNA fragment containing the dpgA gene was amplified using the 5AOX1 and 3AOX1 primers. The PCR product was subjected to DNA sequencing on both strands using the 5AOX1 and 3AOX1 as sequencing primers (Table 3).

Construction of plasmids for co-expressing D-PhgAT with GroEL and GroES

The dpgA gene amplified from the pUC57_D-PhgAT plasmid was cloned into Eco RI site of the pAO815 to construct the pAO_D-PhgAT plasmid. The groEL and groES genes encoding the GroEL and GroES chaperonins were individually amplified from the pGro7 plasmid using the forward and reverse primers (FgroEL _GAP, RgroEL _GAP and FgroES _GAP, RgroES _GAP) containing Eco RI and Xba I sites for cloning separately into pGAPZ B to yield the pGAPZ B_GroEL and pGAPZ B_GroES, respectively. The pGAPZ B_GroES plasmid was cut with Bgl II and Bam HI and the resulting 1.2 kb of GroES expression cassette was ligated into the Bam HI-digested pGAPZ B_GroEL to generate the pGAPZ B_GroEL_GroES. The combined expression cassette of GroEL and GroES was cloned into the Bam HI-digested pAO815_D-PhgAT to create the pAO_D-PhgAT_GAP_ELS [see Additional file 1]. The construction of pAO_D-PhgAT_AOX_ELS was done by a similar procedure except that the groEL and groES genes were cloned into the pAO815, instead of the pGAPZ B, to place the chaperonin genes under the control of the AOX1 promoter. (In the cloning of dpgA, groEL, groES genes into the pAO815, the pAO815 plasmid was cut with Eco RI. The dpgA, groEL, groES were amplified with primers (Table 3) that incorporated an Eco RI site at one end and a Bsa I site at the other end of the PCR products. The Bsa I digested end is compatible with the Eco RI overhang and can be ligated to the Eco RI site but after ligation the Eco RI recognition sequence was destroyed. Orientation of the inserted gene can be determined by double digestions of the recombinant plasmid with Eco RI and Bam HI.) The pAO_D-PhgAT_GAP_ELS and pAO_D-PhgAT_AOX_ELS plasmids were each linearized with Stu I and transformed into P. pastoris KM71. Transformants were selected on minimal dextrose (MD) without histidine plates. PCR analyses using gene-specific primers were done to confirm the presence of dpgA, groEL and groES genes integrated in the P. pastoris chromosome.

In vivo generation of P. pastoris KM71 containing multiple copies of dpgA, groEL and groES genes

The GroEL and GroES expression cassettes were PCR amplified from the pGAPZ B_GroEL_GroES using the forward and reverse primers F_ELS_PICZ and R_ELS_PICZ (Table 3) containing Xho I and Not I sites, respectively, for cloning into pPICZ_26S rDNA. The resulting pPICZ_26S rDNA_GAP_GroELS [see Additional file 2] was linearized with either Sac I or Sfo I for integration at the 5AOX1 or 26S rDNA locus, respectively, in the chromosome of the recombinant P. pastoris KM71 chromosomally harboring multiple copies of dpgA gene previously generated by transforming the KM71 host with pPIC3.5K_D-PhgAT. The transformants were first selected on YPD plates containing 25 μg mL-1 of zeocin. Subsequently, the resistant clones were re-streaked on YPD plates with higher concentration of zeocin (100, 500, 1000, 2000 and 5000 μg mL-1) to select for clones having multiple copies of groEL and groES genes. The copy numbers of the genes integrated were determined by quantitative real-time PCR.

Real-time PCR

Quantitative real time-PCR was performed in duplicates using the QuantiTect SYBR Green PCR Kit (QIAGEN) in 20 μL reaction mixture containing 2 ng of genomic DNA and 0.5 μM of each primer. The thermal cycling conditions started with 15 min at 95°C followed by 40 cycles of 30 s at 95°C, 30 s at 60°C and 45 s at 72°C (Rotor-Gene RG-3000, Corbett Research). After the amplification, a melting curve analysis with a temperature gradient of 0.1°C s-1 from 65°C to 95°C was examined to exclude the amplification of nonspecific products. For correct determination of the starting copy quantity, the reference gene actin was quantified in parallel. The normalized copy number was calculated by relative quantification as described by Livak and Schmittgen [43] with the following formula; n = 2-ΔΔCt where ΔΔCt = (Ct target sample – Ct reference sample) – (Ct target calibrator – Ct reference calibrator). Ct was defined as the point at which the fluorescence level rose above the baseline. The P. pastoris KM71 chromosomally harboring single copy each of the dpgA, groEL, groES gene from the pAO_D-PhgAT_GAP_ELS plasmid was used as the calibrator.

Expression of D-PhgAT and GroEL-ES in P. pastoris KM71

Each constructed strain was grown in 200 mL of BMGY (1% yeast extract, 2% peptone, 100 mM potassium phosphate, pH 6.0, 1.34% YNB, 4 x 10-5% biotin and 1% glycerol) medium contained in a 1000 mL shake flask with 3 extra deep side baffles and 38 mm DeLong neck (Bellco, Part no. 2543–01000) and incubated at 30°C and 200 rpm shaking until the culture reached an OD600nm of 6. Cells were harvested by centrifugation at 2000 × g for 5 min at room temperature. The cells were resuspended in 40 mL of BMMY (0.5% methanol) medium to an OD600nm of 30, transferred into a 500 mL shake flask with 3 extra deep side baffles and 38 mm DeLong neck (Bellco, Part no. 2543–00500) and incubated at the desired temperature to induce the expression of the recombinant D-PhgAT and GroEL-ES. At specified time point, the culture was harvested by centrifugation. For time course study of enzyme expression, methanol was added to the culture to a final concentration of 0.5% at every 24 h in addition to that at the beginning of the induction of gene expression. For viable cell count determination, culture samples were 10-fold serially diluted with 100 mM potassium phosphate, pH 6, and 100 μL aliquots of the 10-6 dilutions were plated on YPD agar. The plates were incubated at 30°C for 72 h before viable cell counts were manually scored. Determinations were done in triplicates.

In the experiments with chemical additives, when the BMGY culture reached an OD600nm of 6, sorbitol was added to a final concentration of 0.5 M and incubated at the desired temperature for 1 h. Cells were pelleted, resuspended in BMMY plus 0.5 M sorbitol, and the incubation was continued for the specified period before the cells were harvested and analyzed. When benzyl alcohol was used as an additive, the BMGY culture at the OD600nm of 6 was added with benzyl alcohol to a final concentration of 0.4 mM and incubated at the desired temperature for 1 h. Cells were pelleted, resuspended in BMMY plus 0.4 mM benzyl alcohol, and incubated at the desired temperature with shaking for the specified period before the cells were harvested and analyzed.

Preparation of cell-free extracts

Protein extraction was accomplished by using a French Press (FA-081A, Thermo Electron Corp.). Cell pellets were washed once and resuspended in chilled lysis buffer (50 mM sodium phosphate, pH 7.4, 1 mM PMSF, 1 mM EDTA and 5% glycerol) with the ratio of cell wet weight to buffer volume of 1:4. Each sample was subjected to 16000 psi cell pressure for 4 passes. The cell lysate was centrifuged at 12000 x g for 10 min at 4°C and the supernatant was collected for determining the D-PhgAT activity.

Protein concentration was determined using the Bradford dye-binding protein assay (Bio-Rad) with bovine serum albumin as a standard.

Purification of the 6xHis-tagged D-PhgAT using immobilized cobalt affinity chromatography

After cultivation, cell-free extract was prepared as described above using lysis buffer without EDTA. Protein purification was performed using an AKTAprime protein chromatography system (GE Healthcare). The BD TALONTM (BD Biosciences) metal affinity resin was packed in a chromatographic column (Tricorn 10/150, GE Healthcare) to a bed volume of 9 mL. The column was pre-equilibrated with 10 column volumes of binding buffer (50 mM sodium phosphate, pH 7.4, containing 10 μM PLP and 0.1 M NaCl). A 10 mL aliquot of the cell-free extract sample was applied onto the column by means of an injection loop at a flow rate of 1 mL·min-1 (linear flow rate = 76.4 cm·h-1). The column was washed with 5 column volumes of the same buffer to remove the unbound materials. The proteins were eluted with a linear gradient of 0–60 mM imidazole contained in the binding buffer for 15 column volumes at the same flow rate. Eluted proteins were collected in 3 mL fractions. Fractions containing D-PhgAT were located by D-PhgAT activity assay and the active fractions were pooled. By means of an Amicon Ultra Centrifugal Filter Device (Millipore) with a 50 kDa cut-off membrane, the pooled active fractions were concentrated and washed 3 times with 20 mL of buffer (50 mM sodium phosphate, pH 7.4, 1 mM PMSF, 1 mM EDTA and 5% glycerol). The purity of the enzyme was assessed by SDS-PAGE.

Determination of D-phenylglycine aminotransferase activity

The D-PhgAT activity assay was performed using the published method [44] with some modifications. In a 1 mL reaction, 20 μL of soluble enzyme fraction was mixed into 980 μL of reaction mixture containing 100 mM CAPSO, pH 9.0, 10 mM D-4-hydroxyphenylglycine, 10 mM α-ketoglutaric acid, 25 μM EDTA and 25 μM PLP. The rate of 4-hydroxybenzoylformate formation was measured as a function of time by monitoring the increase in the absorbance at 340 nm using a spectrophotometer (Biospec-1601, Shimadzu Corp., Japan).

SDS-polyacrylamide gel electrophoresis

Total cellular proteins were analyzed by preparing the samples as followed [45]. A 3 mg wet weight of cell pellet was washed once and resuspended in 0.3 mL of distilled water, then an equal volume of 0.2 M NaOH was added. After 5 min incubation at room temperature, the cells were collected and the supernatant was carefully removed. A 70 μL volume of SDS sample buffer was added to each pellet and mixed by repeatedly pipetting. The samples were boiled for 3 min to solubilize the cell contents, and centrifuged briefly. A 15 μL of cell extract in the sample buffer of each sample was subjected to SDS-polyacrylamide gel electrophoresis in 4% stacking- and 12% separating gel (Mini-Protein II Dual Slab Cell, Bio-Rad) at 150 V for 1 h and the gel was stained with Coomassie Brilliant Blue.

To distinguish between soluble and insoluble proteins, the cell lysate obtained after cell disruption by French Press was centrifuged at 12000 x g for 10 min at 4°C. The supernatant containing soluble proteins was carefully separated from the pellet containing insoluble proteins. Lysis buffer equal to the volume of the supernatant removed was added to dissolve the pellets. The protein samples from the soluble and insoluble fractions were mixed with SDS-sample buffer before boiling for 10 min, and then centrifuged briefly. For each sample, 30 microgram of protein was loaded into the gel.

References

  1. Wiyakrutta S, Meevootisom V: A stereo-inverting D-phenylglycine aminotransferase from Pseudomonas stutzeri ST-201: purification, characterization and application for D-phenylglycine synthesis. J Biotechnol 1997,55(3):193-203. 10.1016/S0168-1656(97)00075-8

    Article  CAS  Google Scholar 

  2. Leuchtenberger W, Huthmacher K, Drauz K: Biotechnological production of amino acids and derivatives: current status and prospects. Appl Microbiol Biotechnol 2005, 69: 1-8. 10.1007/s00253-005-0155-y

    Article  CAS  Google Scholar 

  3. Soda K, Esaki N: Pyridoxal enzymes acting on D-amino acids. Pure Appl Chem 1994, 66: 709-714. 10.1351/pac199466040709

    Article  CAS  Google Scholar 

  4. Coulter-Mackie MB, Lian Q, Wong SG: Overexpression of human alanine:glyoxylate aminotransferase in Escherichia coli : renaturation from guanidine-HCl and affinity for pyridoxal phosphate co-factor. Protein Expr Purif 2005,41(1):18-26. 10.1016/j.pep.2004.11.004

    Article  CAS  Google Scholar 

  5. Cregg JM, Cereghino JL, Shi J, Higgins DR: Recombinant protein expression in Pichia pastoris . Mol Biotechnol 2000, 16: 23-52. 10.1385/MB:16:1:23

    Article  CAS  Google Scholar 

  6. Macauley-Patrick S, Fazenda ML, McNeil B, Harvey LM: Heterologous protein production using the Pichia pastoris expression system. Yeast 2005, 22: 249-270. 10.1002/yea.1208

    Article  CAS  Google Scholar 

  7. Gellissen G: Heterologous protein production in methylotrophic yeasts. Appl Microbiol Biotechnol 2000, 54: 714-750.

    Google Scholar 

  8. Hong F, Meinander NQ, Jonsson LJ: Fermentation strategies for improved heterologous expression of laccase in Pichia pastoris . Biotechnol Bioeng 2002, 79: 438-449. 10.1002/bit.10297

    Article  CAS  Google Scholar 

  9. Li Z, Xiong F, Lin Q, de Anjou M, Daugulis AJ, Yang DSC, Hew CL: Low-temperature increases the yield of biologically active herring antifreeze protein in Pichia pastoris . Protein Expr Purif 2001, 21: 438-445. 10.1006/prep.2001.1395

    Article  Google Scholar 

  10. Shi X, Karkut T, Chamankhah M, Alting-Mees M, Hemmingsen SM, Hegedus D: Optimal conditions for the expression of a single-chain antibody (scFv) gene in Pichia pastoris . Protein Expr Purif 2003, 28: 321-330. 10.1016/S1046-5928(02)00706-4

    Article  CAS  Google Scholar 

  11. Ramon R, Ferrer P, Valero F: Sorbitol co-feeding reduces metabolic burden caused by the overexpression of a Rhizopus oryzae lipase in Pichia pastoris . J Biotechnol 2007, 130: 39-46. 10.1016/j.jbiotec.2007.02.025

    Article  CAS  Google Scholar 

  12. Loewen MC, Liu X, Davies PL, Daugulis AJ: Biosynthetic production of type II fish antifreeze protein: fermentation by Pichia pastoris . Appl Microbiol Biotechnol 1997, 48: 480-486. 10.1007/s002530051083

    Article  CAS  Google Scholar 

  13. Li P, Anumanthan A, Gao X-G, Ilangovan K, Suzara VV: Expression of recombinant proteins in Pichia pastoris . Appl Biochem Biotechnol 2007, 142: 105-124. 10.1007/s12010-007-0003-x

    Article  CAS  Google Scholar 

  14. Hartner FS, Ruth C, Langenegger D, Johnson SN, Hyka P, Lin-Cereghino GP, Lin-Cereghino J, Kovar K, Cregg JM, Glieder A: Promoter library designed for fine-tuned gene expression in Pichia pastoris . Nucleic Acids Res 2008, 36: e76. 10.1093/nar/gkn369

    Article  Google Scholar 

  15. Renugopalakrishnan V, Garduno-Juarez R, Narasimhan G, Verma CS, Wei X, Li P: Rational design of thermally stable proteins: relevance to biotechnology. J Nanosci Nanotechnol 2005, 5: 1759-1767. 10.1166/jnn.2005.441

    Article  CAS  Google Scholar 

  16. Trevino SR, Martin Scholtz J, Nick Pace C: Measuring and increasing protein solubility. J Pharm Sci 2008, 97: 4155-4166. 10.1002/jps.21327

    Article  CAS  Google Scholar 

  17. Roodveldt C, Aharoni A, Tawfik DS: Directed evolution of proteins for heterologous expression and stability. Curr Opin Struct Biol 2005, 15: 50-56. 10.1016/j.sbi.2005.01.001

    Article  CAS  Google Scholar 

  18. Waldo GS: Genetic screens and directed evolution for protein solubility. Curr Opin Chem Biol 2003, 7: 33-38. 10.1016/S1367-5931(02)00017-0

    Article  CAS  Google Scholar 

  19. Rotticci-Mulder JC, Gustavsson M, Holmquist M, Hult K, Martinelle M: Expression in Pichia pastoris of Candida antarctica lipase B and lipase B fused to a cellulose-binding domain. Protein Expr Purif 2001, 21: 386-392. 10.1006/prep.2000.1387

    Article  CAS  Google Scholar 

  20. Yang D, Peng M, Yang H, Yang Q, Xu J: Expression, purification and characterization of Gloydius shedaoensis venom gloshedobin as Hsp70 fusion protein in Pichia pastoris . Protein Expr Purif 2009, 66: 138-142. 10.1016/j.pep.2009.03.003

    Article  CAS  Google Scholar 

  21. Li Z, Leung W, Yon A, Nguyen J, Perez VC, Vu J, Giang W, Luong LT, Phan T, Salazar KA, Gomez SR, Au C, Xiang F, Thomas DW, Franz AH, Lin-Cereghino J, Lin-Cereghino GP: Secretion and proteolysis of heterologous proteins fused to the Escherichia coli maltose binding protein in Pichia pastoris . Protein Expr Purif 2010, 72: 113-124. 10.1016/j.pep.2010.03.004

    Article  CAS  Google Scholar 

  22. Esposito D, Chatterjee DK: Enhancement of soluble protein expression through the use of fusion tags. Curr Opin Biotechnol 2006, 17: 353-358. 10.1016/j.copbio.2006.06.003

    Article  CAS  Google Scholar 

  23. Gasser B, Saloheimo M, Rinas U, Dargosits M, Rodriguez-Carmona E, Baumann K, Giuliani M, Parrilli E, Branduardi P, Lang C, Porro D, Ferrer P, Tutino ML, Mattanovich D, Villaverde A: Protein folding and conformational stress in microbial cells producing recombinant proteins: a host comparative overview. Microb Cell Fact 2008, 7: 11. 10.1186/1475-2859-7-11

    Article  Google Scholar 

  24. Young JC, Agashe VR, Siegers K, Hartl FU: Pathways of chaperone-mediated protein folding in the cytosol. Nat Rev Mol Cell Biol 2004, 5: 781-791. 10.1038/nrm1492

    Article  CAS  Google Scholar 

  25. Damasceno LM, Anderson KA, Ritter G, Cregg JM, Old LJ, Batt CA: Cooverexpression of chaperones for enhanced secretion of a single-chain antibody fragment in Pichia pastoris . Appl Microbiol Biotechnol 2007, 74: 381-389. 10.1007/s00253-006-0652-7

    Article  CAS  Google Scholar 

  26. Zhang W, Zhao HL, Xue C, Xiong XH, Yao XQ, Li XY, Chen HP, Liu ZM: Enhanced secretion of heterologous proteins in Pichia pastoris following overexpression of Saccharomyces cerevisiae chaperone proteins. Biotechnol Prog 2006, 22: 1090-1095. 10.1021/bp060019r

    Article  CAS  Google Scholar 

  27. Gustafsson C, Govindarajan S, Minshull J: Codon bias and heterologous protein expression. Trends Biotechnol 2004, 22: 346-353. 10.1016/j.tibtech.2004.04.006

    Article  CAS  Google Scholar 

  28. Daly R, Hearn MT: Expression of heterologous proteins in Pichia pastoris : a useful experimental tool in protein engineering and production. J Mol Recognit 2005, 18: 119-138. 10.1002/jmr.687

    Article  CAS  Google Scholar 

  29. Vassileva A, Chugh DA, Swaminathan S, Khanna N: Expression of hepatitis B surface antigen in the methylotrophic yeast Pichia pastoris using the GAP promoter. J Biotechnol 2001,88(1):21-35. 10.1016/S0168-1656(01)00254-1

    Article  CAS  Google Scholar 

  30. Mansur M, Cabello C, Hernandez L, Pais J, Varas L, Valdes J, Terrero Y, Hidalgo A, Plana L, Besada V, Garcia L, Lamazares E, Castellanos L, Martinez E: Multiple gene copy number enhances insulin precursor secretion in the yeast Pichia pastoris . Biotechnol Lett 2005, 27: 339-345. 10.1007/s10529-005-1007-7

    Article  CAS  Google Scholar 

  31. Sunga AJ, Tolstorukov I, Cregg JM: Posttransformational vector amplification in the yeast Pichia pastoris . FEMS Yeast Res 2008, 8: 870-876. 10.1111/j.1567-1364.2008.00410.x

    Article  CAS  Google Scholar 

  32. de Marco A, Vigh L, Diamant S, Goloubinoff P: Native folding of aggregation-prone recombinant proteins in Escherichia coli by osmolytes, plasmid- or benzyl alcohol-overexpressed molecular chaperones. Cell Stress Chaperones 2005, 10: 329-339. 10.1379/CSC-139R.1

    Article  CAS  Google Scholar 

  33. Zhang W, Inan M, Meagher M: Fermentation strategies for recombinant protein expression in the methylotrophic yeast Pichia pastoris . Biotechnol Bioprocess Eng 2000,5(4):275-287. 10.1007/BF02942184

    Article  CAS  Google Scholar 

  34. Brierley RA, Bussineau C, Kosson R, Melton A, Siegel RS: Fermentation development of recombinant Pichia pastoris expressing the heterologous gene: bovine lysozyme. Ann N Y Acad Sci 1990, 589: 350-362. 10.1111/j.1749-6632.1990.tb24257.x

    Article  CAS  Google Scholar 

  35. Cregg JM, Vedvick TS, Raschke WC: Recent advances in the expression of foreign genes in Pichia pastoris . Biotechnology (N Y) 1993,11(8):905-910. 10.1038/nbt0893-905

    Article  CAS  Google Scholar 

  36. Diamant S, Eliahu N, Rosenthal D, Goloubinoff P: Chemical chaperones regulate molecular chaperones in vitro and in cells under combined salt and heat stresses. J Biol Chem 2001,276(43):39586-39591. 10.1074/jbc.M103081200

    Article  CAS  Google Scholar 

  37. Oganesyan N, Ankoudinova I, Kim SH, Kim R: Effect of osmotic stress and heat shock in recombinant protein overexpression and crystallization. Protein Expr Purif 2007,52(2):280-285. 10.1016/j.pep.2006.09.015

    Article  CAS  Google Scholar 

  38. Hohmann S: Osmotic stress signaling and osmoadaptation in yeasts. Microbiol Mol Biol Rev 2002,66(2):300-372. 10.1128/MMBR.66.2.300-372.2002

    Article  CAS  Google Scholar 

  39. Mattanovich D, Gasser B, Hohenblum H, Sauer M: Stress in recombinant protein producing yeasts. J Biotechnol 2004,113(1–3):121-135.

    Article  CAS  Google Scholar 

  40. Hartner FS, Glieder A: Regulation of methanol utilisation pathway genes in yeasts. Microb Cell Fact 2006, 5: 39. 10.1186/1475-2859-5-39

    Article  Google Scholar 

  41. Moskvina E, Imre EM, Ruis H: Stress factors acting at the level of the plasma membrane induce transcription via the stress response element (STRE) of the yeast Saccharomyces cerevisiae . Mol Microbiol 1999,32(6):1263-1272. 10.1046/j.1365-2958.1999.01438.x

    Article  CAS  Google Scholar 

  42. Kongsaeree P, Samanchart C, Laowanapiban P, Wiyakrutta S, Meevootisom V: Crystallization and preliminary X-ray crystallographic analysis of D-phenylglycine aminotransferase from Pseudomonas stutzeri ST201. Acta Crystallographica 2003,59(Pt 5):953-954.

    Google Scholar 

  43. Livak KJ, Schmittgen TD: analysis of relative gene expression data using real-time quantitative PCR and the 2-ΔΔCT method. Methods 2001,25(4):402-408. 10.1006/meth.2001.1262

    Article  CAS  Google Scholar 

  44. Khampha W, Wiyakrutta S, Meevootisom V: Spectrophotometric enzymatic cycling method using L-glutamate dehydrogenase and D-phenylglycine aminotransferase for determination of L-glutamate in foods. Anal Chim Acta 2004,520(1–2):133-139.

    Article  CAS  Google Scholar 

  45. Matsuo Y, Asakawa K, Toda T, Katayama S: A rapid method for protein extraction from fission yeast. Biosci Biotechnol Biochem 2006,70(8):1992-1994. 10.1271/bbb.60087

    Article  CAS  Google Scholar 

Download references

Acknowledgements

This research was financially supported by the Thailand Research Fund Grant No. RSA4780014 to SW and the Royal Golden Jubilee Ph.D. Program (Grant No. PHD/0007/2549) to KJ, and the Center of Excellence for the Agricultural Biotechnology, Science and Technology, Postgraduate Education and Research Development Office (PERDO), Commission on Higher Education, Ministry of Education, Thailand. We are also grateful to Prof. Watanalai Panbangred (Dept. of Biotechnology, Mahidol University) for providing the pPICZ_26S rDNA plasmid.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Suthep Wiyakrutta.

Additional information

Competing interests

The authors declare that they have no competing interests.

Authors' contributions

KJ designed and performed the experiments, analyzed data and drafted the manuscript. PL participated in planning the experiments and interpretation of results. VM criticized and gave suggestions on the results. SW conceived the study, followed up, supervised the research work and validated all data. KJ and SW wrote the paper. All authors read and approved the final manuscript.

Electronic supplementary material

12934_2011_720_MOESM1_ESM.pdf

Additional file 1: Genetic maps of pAO_D-PhgAT_AOX_ELS and pAO_D-PhgAT_GAP_ELS plasmids. (A) In the pAO_D-PhgAT_AOX_ELS, the dpgA gene was under the control of an AOX1 promoter, the groEL and groES were individually under the control of an AOX1 promoter. (B) In the pAO_D-PhgAT_GAP_ELS, the dpgA gene was under the control of an AOX1 promoter while the groEL and groES were individually under the control of a GAP promoter. (PDF 833 KB)

Additional file 2: Genetic map of the pPICZ_26S rDNA_GAP_GroELS plasmid.(PDF 356 KB)

12934_2011_720_MOESM3_ESM.pdf

Additional file 3: DNA sequence alignment comparing the wild-type Pseudomonas stutzeri dpgA gene with the synthetic dpgA gene codon-optimized for expression in P. pastoris. The codon-optimized dpgA gene was modified at the C-terminus with (His)6-Cys coding sequence before the stop codon to facilitate protein purification by immobilized ion affinity chromatography and to serve as a site specific for enzyme immobilization at the terminal Cys. (PDF 26 KB)

Authors’ original submitted files for images

Rights and permissions

Open Access This article is published under license to BioMed Central Ltd. This is an Open Access article is distributed under the terms of the Creative Commons Attribution License ( https://creativecommons.org/licenses/by/2.0 ), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Reprints and permissions

About this article

Cite this article

Jariyachawalid, K., Laowanapiban, P., Meevootisom, V. et al. Effective enhancement of Pseudomonas stutzeri D-phenylglycine aminotransferase functional expression in Pichia pastoris by co-expressing Escherichia coli GroEL-GroES. Microb Cell Fact 11, 47 (2012). https://doi.org/10.1186/1475-2859-11-47

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/1475-2859-11-47

Keywords